An emergency response worker carries an air monitoring device at the site of a crude oil spill at a Trans Mountain Pipeline pump station in Abbotsford, on Sunday, June 14, 2020. THE CANADIAN PRESS/Darryl Dyck

An emergency response worker carries an air monitoring device at the site of a crude oil spill at a Trans Mountain Pipeline pump station in Abbotsford, on Sunday, June 14, 2020. THE CANADIAN PRESS/Darryl Dyck

Failed fitting caused 190,000-litre spill at Trans Mountain site in B.C.: TSB

VANCOUVER — A Transportation Safety Board report says the failure of a fitting on a section of narrow tubing at a Trans Mountain pumping station in British Columbia was the cause of a crude oil spill last year.

The investigation report into the spill on June 12, 2020, at the Trans Mountain Sumas pump station in Abbotsford confirms as much as 190,000 litres of crude, roughly 1,200 barrels, leaked when the fitting separated on the one-inch tube.

A board report released Tuesday says tests show the compression fitting was not properly tightened when it was installed in 2015 on a tube that carries a small amount of oil to a section of the pump station for analysis.

The pipeline was shut down within an hour of the spill at Trans Mountain’s control centre in Edmonton, but the report says it took another four hours to find and manually close valves to the tube, spilling oil into a culvert, the water table and a neighbouring agricultural field.

No one was hurt and no evacuation was ordered, but the safety board report says a “multi-year remediation plan” will be needed to recover contaminants in the area surrounding the pump station.

Trans Mountain’s post-spill improvements include remotely operated closure valves and a lined containment area around the above-ground tubes, along with development of a system to check the condition of existing tubing systems.

A safety message at the end of the report says it’s “important” that pipeline companies inspect tubing systems to ensure proper installation.

“In the event of an unplanned product release, it is essential that station (remote shutdown) and isolation systems be properly configured to minimize the quantity of the release,” the report says.

It also says secondary containment systems, such as the oil-water separator that was overwhelmed at the Sumas pump station, “must have a means of isolation in order to prevent any off-site migration of the released product.”

Many of the upgrades planned for the Sumas pump station are expected to be complete by this summer, the report says.

Just Posted

Ella Stoner, five, is ready to cut off her hair and donate it to A Child’s Voice Foundation. (Photo by Lauren Stoner Photography)
Central Alberta girl to donate her ‘princess hair’ to A Child’s Voice Foundation

A five-year-old girl from Rimbey has never had a haircut before. Now,… Continue reading

Asymptomatic testing will now be available for "priority groups" who are most likely to spread the COVID-19 virus to vulnerable or at-risk populations. File photo by THE CANADIAN PRESS
Alberta adds 1,195 new COVID-19 cases Saturday

Red Deer has dropped to 760 active cases

Lacombe-Ponoka MLA Ron Orr
Central Alberta MLAs comment on UCP members kicked out of caucus

A pair of central Alberta MLAs have commented on the two United… Continue reading

Contributed photo
Johanna Hannaford: Central Alberta designer offers inclusive clothing

By Stephanie Rhodes Local designer Johanna Hannaford’s inclusive clothing creations are smashing… Continue reading

Red life-ring with splash
Started from the bottom: How a family business started and grew in central Alberta

By Carina Moran We started our business in the basement of our… Continue reading

Vancouver Canucks' Zack MacEwen (71), Travis Boyd (72) and Jimmy Vesey (24) celebrate a goal against the Edmonton Oilers during third period NHL action in Edmonton on Saturday, May 15, 2021.THE CANADIAN PRESS/Jason Franson
Big third period lifts Vancouver Canucks to 4-1 victory over Edmonton Oilers

Canucks 4 Oilers 1 EDMONTON — Matthew Highmore scored twice in the… Continue reading

A vial of the Medicago vaccine sits on a surface. CARe Clinic, located in Red Deer, has been selected to participate in the third phase of vaccine study. (Photo courtesy www.medicago.com)
Canada’s vaccine rollout operation won’t miss a beat with new military leader: expert

DARTMOUTH — The sudden departure of the senior military officer in charge… Continue reading

Quebec Premier Francois Legault speaks during a news conference on the COVID-19 pandemic, Tuesday, September 29, 2020 at the legislature in Quebec City. THE CANADIAN PRESS/Jacques Boissinot
Quebec premier argues province has power to amend constitution in letter to Trudeau

MONTREAL — Quebec Premier François Legault has written a letter to Prime… Continue reading

A demonstrator stands in front of riot police officers during a banned protest in support of Palestinians in the Gaza Strip, in Paris, Saturday, May, 15, 2021. Marches in support of Palestinians in the Gaza Strip were being held Saturday in a dozen French cities, but the focus was on Paris where riot police countered organizers who said they would defy a ban on the protest, ordered on the grounds that it risked turning violent. (AP Photo/Rafael Yaghobzadeh)
Police fire tear gas on banned Palestinian march in Paris

PARIS (AP) — French riot police fired tear gas and used water… Continue reading

Photo by The Associated Press
NYC Pride parade bans police; Gay officers ‘disheartened’

NEW YORK (AP) — Organizers of New York City’s Pride events said… Continue reading

Welcoming cowboy boots at the historic and colourful Last Chance Saloon in the ghost town of Wayne near Drumheller, Alta., on Thursday, Sept. 19, 2019. The bar and hotel are up for sale. THE CANADIAN PRESS/Jeff McIntosh
‘It was a going concern’: Remaining bar and hotel in Alberta coal ghost town for sale

WAYNE, Alta. — Built during the First World War, it survived the… Continue reading

A letter from a bottle that washed up in New Brunswick in 2017 is shown in an undated handout photo. A team of researchers from Université du Québec à Rimouski are trying to solve the mystery of whether a letter in a bottle that washed up in New Brunswick in 2017 was indeed from a young victim of Titanic shipwreck or simply a hoax. THE CANADIAN PRESS/HO, N. Beaudry, UQAR *MANDATORY CREDIT*
Real or hoax? Quebec scholars probe mystery letter allegedly from Titanic passenger

MONTREAL — Researchers from Université du Québec à Rimouski are trying to… Continue reading

Minister of Transport Marc Garneau takes part in a press conference on Parliament Hill in Ottawa on Tuesday, Nov. 26, 2019. Advocates, experts and opposition MPs say correspondence showing close communication between the federal Transport Department and the Canadian Transportation Agency regarding passenger refunds throws into question the independence of the CTA, an arm’s-length body. THE CANADIAN PRESS/Sean Kilpatrick
Emails reveal close communication between government, transport regulator on refunds

OTTAWA — Advocates, experts and opposition MPs say correspondence showing close communication… Continue reading

Most Read