Skip to content

BP-like blowout could happen again: panel

Decisions intended to save time and money created an unreasonable amount of risk that triggered the largest offshore oil spill in U.S. history, a disaster that could happen again without significant reforms by industry and government, the presidential panel investigating the BP blowout concluded Wednesday.
Gulf Oil Spill
The Deepwater Horizon oil rig burning after an explosion in the Gulf of Mexico

WASHINGTON — Decisions intended to save time and money created an unreasonable amount of risk that triggered the largest offshore oil spill in U.S. history, a disaster that could happen again without significant reforms by industry and government, the presidential panel investigating the BP blowout concluded Wednesday.

The commission findings — the result of a probe requested by President Barack Obama after the April 20 rig explosion — described systemic problems within the offshore energy industry and government regulators who oversee it.

Poor decisions led to technical problems that the commission, and inquires by BP and Congress, have identified as contributing to the accident that killed 11 people and led to more than 200 million gallons (800 million litres) of oil spewing from BP’s well a mile beneath the Gulf of Mexico.

BP, Halliburton and Transocean, the three key companies involved with the well and the rig that exploded, each made individual decisions that increased risks of a blowout but saved significant time or money.

But ultimately, the Deepwater Horizon disaster came down to a single failure, the panel says — management. When decisions were made, no one was considering the risk they were taking.

“The blowout was not the product of a series of abberational decisions made by a rogue industry or government officials that could not have been anticipated or expected to occur again. Rather, the root causes are systemic, and absent significant reform in both industry practices and government policies, might well recur,” the commission concluded in a 48-page excerpt of its final report, obtained by The Associated Press. A final report is due to the president by Jan. 11.

Interior Department spokeswoman Kendra Barkoff said the report focused on areas in which the agency in charge of offshore drilling has already made improvements.

“The agency has taken unprecedented steps and will continue to make the changes necessary to restore the American people’s confidence in the safety and environmental soundness of oil and gas drilling and production on the Outer Continental Shelf, while balancing our nation’s important energy needs,” Barkoff said in a statement.

The panel underscores its central conclusion with a quote from an email written by BP engineer Brett Cocales on April 16, just days before the disaster.

“But, who cares, it’s done, end of story, will probably be fine and we’ll get a good cement job,” Cocales wrote, after he disagreed with BP’s decision to use fewer centralizers than recommended. Centralizers are used to centre the pipe to ensure a good cement job. The cement failed at the bottom of the Macondo well, allowing oil and gas to enter it, according to investigations.

The suggestion that the BP disaster may not be an isolated incident runs counter to assurances by the oil industry, which has worked hard to portray the accident as a rare occurrence.

“This clearly was a rare incident,” the president of the American Petroleum Institute, Jack Gerard, said Tuesday when his organization published a new report urging Congress and the Obama administration to open more areas to oil and gas drilling.

Outside experts in technological disasters were split by the report’s excerpt. They lauded the commission’s focus on organizational and managerial failures instead of blaming the rig workers. But they were divided whether the panel went far enough in criticizing the companies for taking time- and money-saving shortcuts.

University of California at Berkeley engineering professor Bob Bea, who has studied and worked on offshore oil rigs for decades and is an international expert on technological disasters, lauded the panel for “articulating the hows and whys.”

“This was a preventable disaster,” said Bea, who ran a Berkeley investigation into the accident. “We failed to manage and we were managed.”